Product name

: LIGHTNING CURE HARDENER - B

Company name of s Address

upplier : The Epoxy Resin Store

540 CRANE STREET

United States of America (USA)

Telephone

E-mail address of person responsible for the SDS

: (951) 677-0440

:support@theepoxyresinstore.com

Skin irritation Eye irritation Skin sensitisation

GHS label elements

Hazard pictograms

Signal word Hazard statements

Precautionary statements

Ca Ca

:

:

Category 2 tegory 2A

tegory 1

H315 May causes skin irritation.

H317 May cause an allergic skin reaction.

Prevention:

P261 Avoid breathing dust/ fume/ gas/ mist/ vapours/ spray.

Substance / Mixture

:

Substance

Chemical name

CAS-No.

Concentration

(% w/w)

Isophorone Diamine

2855-13-2

30

-

50

TRADE SECRET

TS

40

-

60

General advice

:

Move out of dangerous area.

Show this safety data sheet to the doctor in attendance. Treat symptomatically.

Get medical attention if symptoms occur.

If inhaled

:

If inhaled, remove to fresh air.

Get medical attention if symptoms occur.

In case of skin contact

:

If skin irritation persists, call a physician. If on skin, rinse well with water.

If on clothes, remove clothes.

In case of eye contact

:

Immediately flush eye(s) with plenty of water. Remove contact lenses.

Keep eye wide open while rinsing.

If eye irritation persists, consult a specialist.

If swallowed

:

Keep respiratory tract clear.

Never give anything by mouth to an unconscious person. If symptoms persist, call a physician.

Most important symptoms and effects, both acute and

delayed

:

None known.

Notes to physician

:

Treat symptomatically.

Suitable extinguishing media

:

Use extinguishing measures that are appropriate to local

circumstances and the surrounding environment.

Unsuitable extinguishing

media

:

High volume water jet

Specific hazards during

firefighting

:

Do not allow run-off from fire fighting to enter drains or water

courses.

Hazardous combustion products

:

No hazardous combustion products are known

Carbon oxides Halogenated compounds

Specific extinguishing

methods

:

No data is available on the product itself.

Further information

:

Collect contaminated fire extinguishing water separately. This must not be discharged into drains.

Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations.

Special protective equipment

for firefighters

:

Wear self-contained breathing apparatus for firefighting if

necessary.

Personal precautions, protective equipment and

emergency procedures

:

Use personal protective equipment.

Refer to protective measures listed in sections 7 and 8.

Environmental precautions

:

Prevent product from entering drains.

Methods and materials for containment and cleaning up

:

Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust).

Keep in suitable, closed containers for disposal.

Advice on protection against

fire and explosion

:

Normal measures for preventive fire protection.

Advice on safe handling

:

Do not breathe vapours/dust.

Avoid exposure - obtain special instructions before use. Avoid contact with skin and eyes.

For personal protection see section 8.

Smoking, eating and drinking should be prohibited in the application area.

Dispose of rinse water in accordance with local and national regulations.

Persons susceptible to skin sensitisation problems or asthma, allergies, chronic or recurrent respiratory disease should not be employed in any process in which this mixture is being used.

Conditions for safe storage

:

Keep container tightly closed in a dry and well-ventilated place. Containers which are opened must be carefully resealed and kept upright to prevent leakage.

Keep in properly labelled containers.

Materials to avoid

:

Strong acids Strong bases

Strong oxidizing agents

Recommended storage temperature

:

36 - 104 °F / 2 - 40 °C

Further information on storage stability

:

No decomposition if stored and applied as directed.

Respiratory protection

:

General and local exhaust ventilation is recommended to maintain vapor exposures below recommended limits. Where concentrations are above recommended limits or are unknown, appropriate respiratory protection should be worn. Follow OSHA respirator regulations (29 CFR 1910.134) and use NIOSH/MSHA approved respirators. Protection provided

by air purifying respirators against exposure to any hazardous chemical is limited. Use a positive pressure air

Material

:

butyl-rubber

Break through time

:

> 8 h

Material

:

Ethyl Vinyl Alcohol Laminate (EVAL)

Break through time

:

> 8 h

Material

:

Nitrile rubber

Break through time

:

10 - 480 min

Material

:

Neoprene

Break through time

:

10 - 480 min

Remarks

:

The suitability for a specific workplace should be discussed with the producers of the protective gloves.

Take note of the information given by the producer concerning permeability and break through times, and of special workplace conditions (mechanical strain, duration of contact).

Eye protection

:

Eye wash bottle with pure water Tightly fitting safety goggles

Wear face-shield and protective suit for abnormal processing problems.

Skin and body protection

:

Impervious clothing

Choose body protection according to the amount and concentration of the dangerous substance at the work place.

Hygiene measures

:

When using do not eat or drink. When using do not smoke.

Wash hands before breaks and at the end of workday.

Appearance

:

liquid

Colour

:

colourless

Odour

:

slight

Odour Threshold

:

No data is available on the product itself.

pH

:

ca. 7 (68 °F / 20 °C)

Concentration: 500 g/l

Freezing point

:

No data is available on the product itself.

Melting point

:

No data is available on the product itself.

Boiling point

:

> 392 °F / > 200 °C

Flash point

: Closed cup: >93°C (>199.4°F

Method: Pensky-Martens closed cup

Evaporation rate Flammability (solid, gas) Flammability (liquids)

Upper explosion limit / Upper flammability limit

Lower explosion limit / Lower flammability limit

Vapour pressure Relative vapour density Relative density

Density Solubility(ies)

Water solubility

Solubility in other solvents

Partition coefficient: n- octanol/water

Auto-ignition temperature

Decomposition temperature

: No data is available on the product itself.

: No data is available on the product itself.

: No data is available on the product itself.

: No data is available on the product itself.

: No data is available on the product itself.

: < 0.0001 hPa (77 °F / 25 °C)

: No data is available on the product itself.

: 1.15 - 1.17 (77 °F / 25 °C)

: 0.99 - 1.2 g/cm3 (77 °F / 25 °C)

: practically insoluble (68 °F / 20 °C)

: No data is available on the product itself.

: log Pow: 3.8 (77 °F / 25 °C)

: does not ignite

: Not Available

Self-Accelerating decomposition temper (SADT)

Viscosity

Viscosity, dynamic Explosive properties Oxidizing properties

Particle size

: No data is available on the product itself.

ature

: 250 - 400 mPa.s (77 °F / 25 °C)

: No data is available on the product itself.

: No data is available on the product itself.

: No data is available on the product itself.

Reactivity

:

No dangerous reaction known under conditions of normal use.

Chemical stability

:

Stable under normal conditions.

Possibility of hazardous reactions

:

No hazards to be specially mentioned.

Conditions to avoid

:

None known.

Incompatible materials

:

Strong acids Strong bases

Strong oxidizing agents

Hazardous decomposition products

:

carbon dioxide carbon monoxide

Halogenated compounds

Information on likely routes of

exposure

:

No data is available on the product itself.

Acute oral toxicityComponents

:

LD50 (Rat, female): > 2,000 mg/kg Method: OECD Test Guideline 420

Assessment: The substance or mixture has no acute oral toxicity

Acute inhalation toxicity

:

No data available

Acute dermal toxicity

: No data available

Method:

Acute toxicity (other routes of

administration)

:

No data available

Genotoxicity in vitro

:

Metabolic activation: with and without metabolic activation Method: OECD Test Guideline 476

Result: positive

Concentration: 0 - 5000 ug/plate

Metabolic activation: with and without metabolic activation Method: OECD Test Guideline 471

Result: positive

Genotoxicity in vivo

:

Cell type: Germ Application Route: Oral

Method: OECD Test Guideline 478 Result: negative

Cell type: Somatic Application Route: Oral Dose: 0 - 5000 mg/kg

Method: OPPTS 870.5395

Result: negative

Frequency of Treatment: 7 days/week Method: OECD Test Guideline 453 Result: negative

Species: Mouse, male Application Route: Dermal Exposure time: 24 month(s) Dose: 0.1 mg/kg

Frequency of Treatment: 3 days/week Method: OECD Test Guideline 453 Result: negative

Species: Rat, female Application Route: Dermal Exposure time: 24 month(s) Dose: 1 mg/kg

Frequency of Treatment: 5 days/week Method: OECD Test Guideline 453 Result: negative

Carcinogenicity -

Assessment

:

No data available

IARC

No component of this product present at levels greater than or

equal to 0.1% is identified as probable, possible or confirmed human carcinogen by IARC.

ACGIH

No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential

carcinogen by ACGIH.

OSHA

No component of this product present at levels greater than or equal to 0.1% is on OSHA’s list of regulated carcinogens.

NTP

No component of this product present at levels greater than or

equal to 0.1% is identified as a known or anticipated carcinogen by NTP.

Effects on fertility

:

Test Type: Two-generation study Species: Rat, male and female Application Route: Oral

Dose: >750 milligram per kilogram

General Toxicity - Parent: No-observed-effect level: 540 mg/kg body weight

General Toxicity F1: No-observed-effect level: 540 mg/kg body weight

Symptoms: No adverse effects Method: OECD Test Guideline 416

Result: No effects on fertility and early embryonic development were detected.

Effects on foetal development

:

Species: Rabbit, female Application Route: Dermal

General Toxicity Maternal: No observed adverse effect level: 30 mg/kg body weight

Method: Other guidelines Result: No teratogenic effects

Species: Rabbit, female Application Route: Oral

General Toxicity Maternal: No observed adverse effect level: 60 mg/kg body weight

Method: OECD Test Guideline 414 Result: No teratogenic effects

Species: Rat, female Application Route: Oral

General Toxicity Maternal: No observed adverse effect level: 180 mg/kg body weight

Method: OECD Test Guideline 414 Result: No teratogenic effects

Reproductive toxicity -

Assessment

:

No data available

Repeated dose toxicity -

Assessment

:

No data available

General Information:

No data available

Inhalation:

No data available

Skin contact:

No data available

Eye contact:

No data available

Ingestion:

No data available

Ingestion:

No data available

Toxicity to fish

:

LC50 (Oncorhynchus mykiss (rainbow trout)): 1.5 mg/l Exposure time: 96 h

Test Type: static test

Test substance: Fresh water Method: OECD Test Guideline 203

Toxicity to daphnia and other aquatic invertebrates

:

EC50 (Daphnia magna (Water flea)): 2.7 mg/l Exposure time: 48 h

Test Type: static test

Test substance: Fresh water

Toxicity to algae

:

EC50 (Selenastrum capricornutum (green algae)): 9.4 mg/l Exposure time: 72 h

Test Type: static test

Test substance: Fresh water Method: EPA-660/3-75-009

M-Factor (Acute aquatic

toxicity)

:

No data available

Toxicity to fish (Chronic

toxicity)

:

No data available

Toxicity to daphnia and other aquatic invertebrates (Chronic toxicity)

:

NOEC (Daphnia magna (Water flea)): 0.3 mg/l Exposure time: 21 d

Test Type: semi-static test Test substance: Fresh water

Method: OECD Test Guideline 211

M-Factor (Chronic aquatic

toxicity)

:

No data available

Toxicity to soil dwelling

organisms

:

No data available

Plant toxicity

:

No data available

Sediment toxicity

:

No data available

Toxicity to terrestrial

organisms

:

No data available

Acute aquatic toxicity

:

No data available

Chronic aquatic toxicity

:

No data available

Toxicity Data on Soil

:

No data available

Other organisms relevant to

the environment

:

No data available

Biodegradability

:

Inoculum: Sewage (STP effluent) Concentration: 20 mg/l

Result: Not readily biodegradable. Biodegradation: 5 %

Exposure time: 28 d

Method: OECD Test Guideline 301F

Biochemical Oxygen

Demand (BOD)

:

No data available

Chemical Oxygen Demand

(COD)

:

No data available

BOD/COD

:

No data available

ThOD

:

No data available

BOD/ThOD

:

No data available

Dissolved organic carbon

(DOC)

:

No data available

Physico-chemical

removability

:

No data available

Stability in water

:

Degradation half life(DT50): 4.83 d (77 °F / 25 °C) pH: 4 Method: OECD Test Guideline 111

Remarks: Fresh water

Degradation half life(DT50): 7.1 d (77 °F / 25 °C) pH: 9 Method: OECD Test Guideline 111

Remarks: Fresh water

Degradation half life(DT50): 3.58 d (77 °F / 25 °C) pH: 7 Method: OECD Test Guideline 111

Remarks: Fresh water

Photodegradation

:

No data available

Impact on Sewage

Treatment

:

No data available

Partition coefficient: n-

octanol/water - Product

:

log Pow: 3.8 (77 °F / 25 °C)

Mobility

:

No data available

Environmental fate and

pathways

:

No data available

Results of PBT and vPvB

assessment

:

No data available

Endocrine disrupting

potential

:

No data available

Adsorbed organic bound

halogens (AOX)

:

No data available

Ozone-Depletion Potential

:

Regulation: 40 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 602 Class I Substances

Remarks: This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the

U.S. Clean Air Act Section 602 (40 CFR 82, Subpt. A, App.A + B).

Additional ecological information - Product

:

An environmental hazard cannot be excluded in the event of

unprofessional handling or disposal.

An environmental hazard cannot be excluded in the event of unprofessional handling or disposal.

Global warming potential

(GWP)

:

No data available

Waste from residues

:

The product should not be allowed to enter drains, water courses or the soil.

Do not contaminate ponds, waterways or ditches with chemical or used container.

Send to a licensed waste management company.

Dispose of as hazardous waste in compliance with local and national regulations.

Dispose of contents/ container to an approved waste disposal plant.

Contaminated packaging

:

Empty remaining contents. Dispose of as unused product. Do not re-use empty containers.

IATA

UN/ID No.

Proper shipping name

Class

Packing group

Labels

Packing instruction (cargo aircraft)

IMDG

UN number

: Not Regulated

: (ISOPHORONEDIAMINE SOLUTION)

Proper shipping name

Class

Packing group

Labels

EmS Code

DOT Classification

UN/ID/NA number

Proper shipping name

:NOT REGULATE DUNDER 110 GALLONS :

(ISOPHORONEDIAMINE SOLUTION)

Class

Packing group Labels

ERG Code

Marine pollutant

(ISOPHORONEDIAMINE SOLUTION) :

NOT REGULATED

NOT REGULTAED NA

NA

Components

CAS-No.

Component RQ (lbs)

Calculated product RQ (lbs)

2855-13-2

100

*

SARA 311/312 Hazards

:

Skin corrosion or irritation

Serious eye damage or eye irritation Respiratory or skin sensitisation

SARA 313

:

This material does not contain any chemical components with

known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313.

CH INV

:

On the inventory, or in compliance with the inventory

DSL

:

All components of this product are on the Canadian DSL

AICS

:

On the inventory, or in compliance with the inventory

NZIoC

:

On the inventory, or in compliance with the inventory

ENCS

:

On the inventory, or in compliance with the inventory

KECI

:

On the inventory, or in compliance with the inventory

PICCS

:

On the inventory, or in compliance with the inventory

IECSC

:

On the inventory, or in compliance with the inventory

TCSI

:

On the inventory, or in compliance with the inventory

TSCA

:

On the inventory, or in compliance with the inventory